Whistling over 60mph with recirculate mode on

[freejack]

My R1S started making a high pitched whistling sound when driving over 60mph after getting the car back from the SC. Taped up every gap from the trunk to the front driver and passenger doors and windows to try to find where it was coming from without any luck. Was about to give up but then noticed that the sound was gone when I turned off recirculate mode. I'm guessing the problem has to do with a bad seal when the car closes air flow from the outside. They did service the HVAC while it was at the SC for another issue and probably did not reassemble properly.

If any of you are experience whistling, you may have the same issue.

Sponsored

 

[Krusty]

Have the same issue. I'll have to add that to my service appointment. Thanks

 

[Prime]

My R1S started making a high pitched whistling sound when driving over 60mph after getting the car back from the SC. Taped up every gap from the trunk to the front driver and passenger doors and windows to try to find where it was coming from without any luck. Was about to give up but then noticed that the sound was gone when I turned off recirculate mode. I'm guessing the problem has to do with a bad seal when the car closes air flow from the outside. They did service the HVAC while it was at the SC for another issue and probably did not reassemble properly.

If any of you are experience whistling, you may have the same issue.

I have to try this. I’ve been going crazy with the whistling over 50mph that just gets worse and worse the faster the truck goes. I’ve tried taping everything as well with no resolve. I was beginning to think it was for whole front door seals but i will definitely try turning off the recirculate.

 

[freejack]

I have to try this. I’ve been going crazy with the whistling over 50mph that just gets worse and worse the faster the truck goes. I’ve tried taping everything as well with no resolve. I was beginning to think it was for whole front door seals but i will definitely try turning off the recirculate.

Hopefully that’ll be the issue. It was driving me crazy also.

 

[Aag12]

Same here. It's raining and weather dropped and noticed that car is quiet again! Idk if mine is solely recirculation mode or just ac...

 

[freejack]

Same here. It's raining and weather dropped and noticed that car is quiet again! Idk if mine is solely recirculation mode or just ac...

Whatever it is it's somehow tied to the HVAC system at least in my case.

 

[DuoRivians]

YES, thank you! This is the cause of my whistling noise too! Finally found the cause. Submitting a ticket now

 

[Oh_Yeah_Rivian]

Was there any update to this on people who submitted tickets? I have whistling above 50 mph with recirculation on. Not sure if service center narrowed it down for y’all

 

[freejack]

Was there any update to this on people who submitted tickets? I have whistling above 50 mph with recirculation on. Not sure if service center narrowed it down for y’all

I have an appointment coming up in a few weeks. Will post updates here.

 

[GatorCat94]

Yes! Confirmed I have the same issue. Whistling stops when I switch ac to fresh air. Which ironically then causes the compressor to ramp up to jet speed. I expect compressor issue to improve when Florida heat and humidity subsides a bit. Waiting to make a service appt to see if anyone can get it fixed first..

 

[DuoRivians]

Bumping this up.

Has anyone had this recirculation whistling issue fixed successfully by their service center?

The South San Francisco SC didn’t fix mine and the issue still exists. I’m going to re-submit the issue to the San Jose SC.

I’m a bit annoyed. But if anyone has had this issue fixed, I’d appreciate being able to relay the tech’s notes to my service center.

Thank you.

 

[Wayne]

My R1S started making a high pitched whistling sound when driving over 60mph after getting the car back from the SC. Taped up every gap from the trunk to the front driver and passenger doors and windows to try to find where it was coming from without any luck. Was about to give up but then noticed that the sound was gone when I turned off recirculate mode. I'm guessing the problem has to do with a bad seal when the car closes air flow from the outside. They did service the HVAC while it was at the SC for another issue and probably did not reassemble properly.

If any of you are experience whistling, you may have the same issue.

Funny, mine did that today when I switched recirculate off. It turned out the passenger window was ever so slightly open. Window up, problem solved.

 

[freejack]

Funny, mine did that today when I switched recirculate off. It turned out the passenger window was ever so slightly open. Window up, problem solved.

Wish that was the case with mine.

Sponsored